Remak DoorMaster D2 Instrucciones de operaciones

INSTALLATION AND OPERATING INSTRUCTIONSAir curtains C1, D204/2013

10Air curtainsInstallation, Media ConnectionFigure 10 - mounting on the threaded bars (C1)Figure 12 - mounting on the threaded bars (D2)Figure 11 - mo

11Air curtainsTable 1 – main switches and protection1) low-voltage switching trigger 2) Lockable main switch with at least 3 mm distant contacts Wirin

12Air curtainsWiring and CommissioningFigure 14 – WAGO terminalsAs standard, the DoorMaster COMFORT air curtains are designed to be controlled by remo

13Air curtainsAccessory Installationstat 80°C, operation thermostat 60°C) is forbidden.  It is forbidden to operate the electric heater without the

14Air curtainsFigure 16 – Thermo-valve sensor installation, C1 Figure 17 – Thermo-valve sensor installation, D2Figure 18 – TVW-R Thermostatic Valve In

15Air curtainsFigure 21 – Room thermostatsRAA 10Heating output control using a room thermostatApplication:- C1-E1 E2 air curtains (electric heater)-

16Air curtainsWiring diagramsFigure 22 – C1-E1 air curtains connectionX1 - Main power connection (supply)L1+L2+L3+N+PE - Input voltage terminals TK-T

17Air curtainsFigure 25 – C1-E2/TR air curtains connectionX1 - Main power connection (supply)L1+L2+L3+N+PE - Input voltage terminals TK-TK - under-vo

18Air curtainsFigure 26 – C1-W and C1-N air curtains connectionWiring diagramsX1 - Main power connection (supply)L+N+PE - Input voltage terminalsDK1-

19Air curtainsFigure 29 – D2-W and D2-N air curtains connectionX1 - Main cower connection (supply)L+N+PE - Input voltage terminalsDK-DK - Door contac

2Air curtainsContentsApplication, Operating Conditions and Construction ...3Designations, st

20Air curtainsTable 3 – Possible control according to air curtain typeWiring diagramsFigure 30 – control of chained C1 air curtains using an internal

21Air curtainsAir Curtain ChainingFigure 31 – Mechanical Connection of C1 seriesObserving all instructions of the Installation Instructions Manual, su

22Air curtainsOperating and Maintenance InstructionsFigure 32 – Mechanical connection pointsFigure 33 – Mechanical connection points, D2D29 side hole

23Air curtainsTable 4 – Operation checks Maintenance and Screening ChecksFigure 34 – Filter insert brace installationScreening Checks and Maintenanc

24Air curtainsNáhradní díly, servisTroubleshooting The heat-exchanging surface of the exchanger can be vacuumed or blown through. To remove deeper d

25Air curtainsSpare parts, service and disposalCheck procedure:Verify the air curtain control possibilities, refer to table #9 on page 20.Using

26Air curtainsPrinting and language mistakes are reserved.These Installation and Operating Instructions (as a whole or a part) must not be printed or

27Air curtains

REMAK a.s.Zuberská 2601, 756 61 Rožnov pod Radhoštěm,tel.: +420 571 877 878, fax: +420 571 877 877,email: [email protected], internet: www.remak.cz Výrob

3Air curtainsApplication, Operating Conditions and ConstructionInformation from the manufacturerDoorMaster door curtains are manufactured in compli-an

4Air curtainsDesignation, Storage and DispatchThe covering sidewalls are laminated. The intake panel has an integrated lter insert (G1). The exhaust

5Air curtainsInstallation, mountingRules for location - correct installationInstall the curtains above the entrance door with the outlet slot near the

6Air curtainsDimensionsFigure 6 - dimensions of the curtains in the C1 series***Figure 7 - basic dimensions of the curtains in the D2 seriesSize AZAV

7Air curtainsArrangementsterminals for the electrical connectionadjustable outlet screenremovable intake panelconnections for the mediaplastic sidewal

8Air curtainsTechnical parametersWater heatingLow-temperatureElectric heating E2Electric heating E1E2E1WN* Acoustic pressure at a distance of 3.0 m,

9Air curtainsTechnical parameters* Acoustic pressure at a distance of 3.0 m, directional factor 2 and absorption surface 200 m2** Acoustic output ac